npav wrote:I've run into a problem with my 2013 LEAF S. The 12v battery dies overnight, back in November I bought a new 12v battery from AutoZone because the original died and there had been no problems since.
Now a few days ago I go to drive the LEAF and it doesn't start, no lights, no door unlock, nothing, just like when the original battery died. So I figured the 12v was low on charge, so I jump started it and drove around for a while to charge it up.
Next morning it's dead again. So this time I jump it and take it to AutoZone to test the battery, they say it's healthy, just needs a charge, so I plug in the portable Stanley battery charge kit and leave it there for about 3 hours or so. Give it a shot and it starts right up, checked the battery voltage and it shows at just over 13v. Figure that's that and call it a night. Next morning the car won't start again and it registers at just 4v.
Then again this whole thing could just be a bad battery from AutoZone and they don't want to admit it...
A "new" battery that is installed in a Leaf MAY need to be fully charged before it is put to use. This would be an unusual case where the seller has old inventory (and had installed the acid!) and the battery has discharged. What is important to understand about the Leaf is that the charging system is quite different than a typical ICE auto and (at least I've proven for my 2012 Leaf - cannot comment on other models!), it is better at MAINTAINING the FLA battery than it is charging a discharged battery.
Next, if you buy a oversized auto battery, it can take a very long time to charge from a discharged state to fully charged with a trickle charger. Let's say you have a 100 ahr FLA battery (I know - it's rated in CCA!) and you use a 1.5 amp "trickle" charger to recharge a fully discharged battery- at best it will take about 60 hours to charge! Also, individual cells in a FLA battery like to be "equalized" periodically with a typical full amperage (15+) auto style charger - up to essentially 15 volts for 1/2 to 2 hours - and that assumes it was near full charge to start with.
Lastly, if you've seen 4 volts on your new battery - take it back and insist on a new one. This is a very destructive voltage for any lead acid battery - for any length of time. It is possible the new battery had a "shorted" cell - or some defect that effectively quickly drains itself - with no external connections.
Good luck and let us know how it works out for you.