Rwolf01
Posts: 4
Joined: Thu Jul 20, 2017 12:55 am
Delivery Date: 08 Jun 2017
Leaf Number: 313943
Location: Palo Alto

Re: 90% charge needed.

Wed Sep 06, 2017 9:35 pm

I came up with a simple HW hack that works fine on my 30 KWH 2016 Leaf. Just mount a mechanical timer switch in series with the handshaking wire that goes from the J1772 plug to the EVSE. I used a 6 hour timer like this:

https://www.amazon.com/Intermatic-FF6H- ... mer+switch

With a 6 KW charger, I gain about 20% of charge per hour. So I just relabeled the switch face as follows:

0:30 80%
1:00 70%
1:30 60%
2:00 50%
2:30 40%
3:00 30%
3:30 20%
4:00 10%
4:30 0%
5:30 100%
6:00 100%

The instructions I gave my non-technical spouse were: "Turn the dial to the remaining charge when you get home and plug it in. It'll stop at around 90%. If you want a full charge, turn it to 100%."

I tired it. It works. When the switch opens the EVSE cuts the power and the car stops charging. Importantly the car does NOT beep or complain and it still realizes the charger is plugged in, so you can't drive away and hurt something. If you add some time, the charge starts right up again. I figure the Leaf just assumes there was a power outage.

Note: You can install the switch at either end. I taped mine to the cable just behind the J1772 plug and ran tiny wires into the handle. The signal is low voltage and low current, so you can use any sort of small wire, like speaker or hookup wire. (Do not mess with the fat wires. Those are the ones that can kill you)

You might *think* "Hey, why mess with the handshaking signal? Just wire the switch to the latch sensor wire instead!" I tired that. It does work, but there is a problem. If you don't finish unplugging the car within 5 or 10 seconds of opening that switch the car starts beeping and flashing the blue LEDs on the dash. (It think the plug is not inserted all the way) I would NOT be popular with my neighbors if the car did that all night long, every night.

Finally, the charge rate I calculated is actually closer to 21% per hour. I rounded it off. Your charge rate will vary depending on the EVSE you have, which charger and battery option you have and even the age of the battery. My car charges at a very steady rate from 0 to 95% but then slows down a bit at the end.

I figure if I ever need a 100% charge and didn't set it up the night before, I just need to start topping it up about 45 minutes before I leave. According to the battery gurus it is still easier on the battery to top it up right before using it than to charge it all the way to 100% the night before.

Before anyone asks, I do NOT recommend using any sort of electronic timer switch for this task. If you want to use some fancy electronics to do the control, stick an old fashioned relay in place of the timer switch. You want the handshaking signal to just see a simple mechanical contact closure.

LeftieBiker
Posts: 8895
Joined: Wed May 22, 2013 3:17 am
Delivery Date: 31 May 2013
Location: Upstate New York, US

Re: 90% charge needed.

Wed Sep 06, 2017 10:18 pm

That's a great idea. It's a shame that most people won't want to mess with the sealed wring to implement it. You could probably buy a J-1772 extension cable, wire the timer to that, and then sell the extension/timer...
Scarlet Ember 2018 Leaf SL W/ Pro Pilot
2009 Vectrix VX-1 W/18 Leaf modules, & 3 EZIP E-bicycles.
PLEASE don't PM me with Leaf questions. Just post in the topic that seems most appropriate.

powersurge
Posts: 979
Joined: Wed Oct 21, 2015 10:24 am
Delivery Date: 06 Dec 2014
Location: Long Island, NY

Re: 90% charge needed.

Tue Sep 12, 2017 7:03 am

whether you live on a hill or not, the difference between 90 and 100 is negligible. So you spend an extra $0.20 cents in electricity and don't get some free regen charging. Does not sound like the effort to get 90% is worth it..

cwerdna
Posts: 7914
Joined: Fri Jun 03, 2011 4:31 pm
Delivery Date: 28 Jul 2013
Location: SF Bay Area, CA

Re: 90% charge needed.

Thu Sep 14, 2017 10:57 pm

powersurge wrote:whether you live on a hill or not, the difference between 90 and 100 is negligible. So you spend an extra $0.20 cents in electricity and don't get some free regen charging. Does not sound like the effort to get 90% is worth it..

The amount can add up over time and if you're at the top of a hill and need to slow down, your friction brakes will require changing MUCH more frequently. That's more than 20 cents.

We already have at least 1 documented case of this here on MNL.

'13 Leaf SV w/premium package (owned)
'13 Leaf SV w/QC + LED & premium packages (lease over, car returned)
'06 Prius

Please don't PM me with Leaf questions. Just post in the topic that seems most appropriate.

borugee
Posts: 47
Joined: Fri Sep 15, 2017 8:06 pm
Delivery Date: 15 Sep 2017
Leaf Number: 303100
Location: Dallas TX

Re: 90% charge needed.

Sat May 12, 2018 8:44 pm

Is Nissan aware that we are writing to them. Are they deaf? We wrote. They released 2018 Leaf. No charge level setting there. Earlier Leafs we can set eV settings in Touch-screen, they have removed them from touch screen and moved to dash-board screen. I don't think Nisaan care about this forum? How do we make them listen to their customers need?
Borugee
2018 SL ; 03/18 Delivery ; Dallas TX

cwerdna
Posts: 7914
Joined: Fri Jun 03, 2011 4:31 pm
Delivery Date: 28 Jul 2013
Location: SF Bay Area, CA

Re: 90% charge needed.

Sat May 12, 2018 11:58 pm

borugee wrote:Is Nissan aware that we are writing to them. Are they deaf? We wrote. They released 2018 Leaf. No charge level setting there...

Nissan is well aware of the request to even provide multiple choices in terms of % SoC for when the car stops charging.

Someone even asked them in the Phoenix town hall (video at viewtopic.php?f=30&t=9694) in Jan 2013.

Instead, Nissan removed the 80% choice starting with model year 2014, most likely to make the car look more competitive in terms of EPA range rating vs. other EVs at the time since most others (except Tesla) don't give you a choice either. And, probably 99% of US EV shoppers wouldn't know this backstory.

https://insideevs.com/2013-nissan-leaf- ... ld-system/
https://insideevs.com/2014-nissan-leaf- ... -84-miles/

Due to the stupid rule, 75 miles in model year 2014 would've looked near bottom of the barrel vs. other similarly priced EVs at the time, while 84 looks ok.

The Bolt has some sort of hilltop reserve mode so that it doesn't charge to full, allowing for some regen after charging has stopped early.

'13 Leaf SV w/premium package (owned)
'13 Leaf SV w/QC + LED & premium packages (lease over, car returned)
'06 Prius

Please don't PM me with Leaf questions. Just post in the topic that seems most appropriate.

LeftieBiker
Posts: 8895
Joined: Wed May 22, 2013 3:17 am
Delivery Date: 31 May 2013
Location: Upstate New York, US

Re: 90% charge needed.

Sun May 13, 2018 2:54 am

The Bolt has some sort of hilltop reserve mode so that it doesn't charge to full, allowing for some regen after charging has stopped early.


And Nissan's refusal to implement a similar Regen-saving mode that would also help the battery is emblematic of Nissan's general "Double down on all mistakes" EV philosophy. I really wish I'd been able to find another EV with the features I want and need.
Scarlet Ember 2018 Leaf SL W/ Pro Pilot
2009 Vectrix VX-1 W/18 Leaf modules, & 3 EZIP E-bicycles.
PLEASE don't PM me with Leaf questions. Just post in the topic that seems most appropriate.

WetEV
Posts: 2085
Joined: Fri May 04, 2012 8:25 am
Delivery Date: 16 Feb 2014
Location: Near Seattle, WA

Re: 90% charge needed.

Sun May 13, 2018 6:19 am

LeftieBiker wrote:
The Bolt has some sort of hilltop reserve mode so that it doesn't charge to full, allowing for some regen after charging has stopped early.


And Nissan's refusal to implement a similar Regen-saving mode that would also help the battery is emblematic of Nissan's general "Double down on all mistakes" EV philosophy. I really wish I'd been able to find another EV with the features I want and need.


Amusing. Nissan has made so many mistakes, but has all the features you want and need.
WetEV
#49
Most everything around here is wet during the rainy season. And the rainy season is long.
2012 Leaf SL Red (Totaled)
2014 Leaf SL Red

powersurge
Posts: 979
Joined: Wed Oct 21, 2015 10:24 am
Delivery Date: 06 Dec 2014
Location: Long Island, NY

Re: 90% charge needed.

Tue May 15, 2018 7:20 am

You know, I have my leaf more than 3 years, and it just hit me...

With all of the computer, and displays the Leaf has, why couldn't they have made a:

Charge to 50%, 60%, 70%, 80...% controls?? There are so many individual reasons to need different levels of charge, that would have been so easy!!

borugee
Posts: 47
Joined: Fri Sep 15, 2017 8:06 pm
Delivery Date: 15 Sep 2017
Leaf Number: 303100
Location: Dallas TX

Re: 90% charge needed.

Tue May 15, 2018 6:35 pm

cwerdna wrote:
borugee wrote:Is Nissan aware that we are writing to them. Are they deaf? We wrote. They released 2018 Leaf. No charge level setting there...

Nissan is well aware of the request to even provide multiple choices in terms of % SoC for when the car stops charging.

Someone even asked them in the Phoenix town hall (video at http://www.mynissanleaf.com/viewtopic.php?f=30&t=9694) in Jan 2013.

Instead, Nissan removed the 80% choice starting with model year 2014, most likely to make the car look more competitive in terms of EPA range rating vs. other EVs at the time since most others (except Tesla) don't give you a choice either. And, probably 99% of US EV shoppers wouldn't know this backstory.

https://insideevs.com/2013-nissan-leaf- ... ld-system/
https://insideevs.com/2014-nissan-leaf- ... -84-miles/

Due to the stupid rule, 75 miles in model year 2014 would've looked near bottom of the barrel vs. other similarly priced EVs at the time, while 84 looks ok.

The Bolt has some sort of hilltop reserve mode so that it doesn't charge to full, allowing for some regen after charging has stopped early.


For electric cars EPA mileage should not be at the miles when the car is new, they should also publish expected miles when car is at 20k, 40k,60k..100k. Nissan will comply then.
Borugee
2018 SL ; 03/18 Delivery ; Dallas TX

Return to “Suggestions for Nissan”