Page 2 of 4

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sat Feb 09, 2019 9:13 am
flydiver wrote:
WetEV wrote:Shunt resisters are 430 ohm across each set of cells. When shunting they draw V^2/R power, or roughly 16/430 or 40 mW each. There are 96 sets of cells, so if all but one was active, total power would be about 3.5 watts.
You did that in your head, right?
Actually no. I did use a calculator. I did check the results in my head.

### Attempt to estimate 'waste' from shunting during cell balancing. Minor?

Posted: Sun Feb 10, 2019 4:08 am
LeftieBiker wrote:I honestly don't know how much power the shunt resistors 'waste,' but given the amount of time they run, the fact that they are only converting power from the highest-SOC cells to heat, etc, I'd say it isn't much. Some balancing algorithms just switch the higher cells out of the circuit, allowing the lower-SOC cells to 'catch up'.
I think it would be possible to figure out from observing ChargePoint data,

ChargePoint provides the amount of kWh that have been delivered. If you were watching the ChargePoint app and noticed that value the first time that the SOC reached 100% and the rate of charge dropped to 0%, that would be the delivered kWh before cell balancing commenced.

Then you could make a note of the total kWh's delivered after the three+ separate times that power is shunted from the most charged cells to achieve balance.

The difference might be part of the 'waste overhead' from cell balancing. My W.A.G. (wild Allan guess) might be 0.3 to 0.5 kWh out of perhaps 13 kWh to go from a SOC of about 20% to 100% to 99% to 100% to 99% to 100% to 99% to 100%.

During the several hours of cell balancing, my observation was that about 1.0 kW/hr was being delivered about half that duration to bring the 'low cells' up to 100%. However, that wouldn't be 'wasted' as actual charge is being delivered.

Actual waste would be during the 'shunting' of cells that were at 100% when heat was brought about to draing cells to achieve balance.

I will try to take a closer look at the ChargePoint log that is recorded to my Andriod 7.1 device. I'm trying to figure out to get a 'screen shot' from my smart-phone ... Power-off + reduce-volume doesn't seem to work. Drat.

I suppose this info could also be derived from a Kill-A-Watt device at the wall-plug.

I don't have the LeafSpy app or ELM-327 connector, but my speculation is LeafSpy might provide reasonable numbers of how many kWh were delivered after the first time a SOC of 100% was achieved.

### Weekly charging to 100% and holding for several hours for cell balancing seems like a bit non-baby'ing of the battery?

Posted: Sun Feb 10, 2019 4:22 am
LeftieBiker wrote:Monthly is good, obviously, although I'd consider it near the infrequent end of good. Once a week is probably the most often anyone would need to do it.
My concern about 'cell balancing' more than monthly ... especially weekly ... is that seems to be 3x more charges to 100% than I prefer to do to 'baby' our Leaf battery.

My typical practice when not doing cell-balancing has been to use the Leaf timer or the ChargePoint app with Level-2 to charge a bit high to about 85% to 90% SOC, and then start driving very shortly afterwards so that the battery is above 80% a very low amount of time. By the time I get home from the charger, the SOC is typically about 80%, depending on the errands I combine with the L2 public charging.

If I cell balance weekly, then 52 times a year the battery is at 99% to 100% for several hours. That seems like perhaps the disadvantage of doing 100% charges might out-weigh the advantage of cell balancing.

My speculation is that with weekly cell-balancing, I might slightly improve my usable range compared to monthly cell balancing, but at the 'price' of reducing my battery lifetime in the long term.

Or am I being overly concerned about 'baby'ing the battery'? I've still got 12 bars at 40,000 miles, and want to delay to loss of a bar for another year or three, if feasible.
Thanks for the data points.
And I would appreciate 'data points' from you and other experienced Leaf owners. I'm curious about how often you 'cell balance'? Weekly? Bi-weekly? Monthly? Less often? More often? Rarely? Before a long day when max range is at a premium?

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 5:37 am
First, I wrote that weekly was the most often I'd suggest balancing if needed - I wasn't suggesting it as best practice. Second, an indicated 100% SOC on a Leaf ranges from about 94% to about 96%, not actually 100%. Last, I do it fairly rarely because I don't drive much: I have yet to even approach 2,000 miles in almost a year. About once every two or three months now is it for me.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 6:04 am
LeftieBiker wrote:First, I wrote that weekly was the most often I'd suggest balancing if needed - I wasn't suggesting it as best practice.
Agree. I realized you weren't advocating weekly balancing. I did want to check if my inference of you suggesting about bi-weekly rather than monthly was closer to what you were in favor of for my moderate annual driving. And my apologies if my comments came across as argumentative or unappreciative of your feedback.
Second, an indicated 100% SOC on a Leaf ranges from about 94% to about 96%, not actually 100%.
Ah ... good point. I hadn't taken that into account. Is that the kind of info available from LeafSpy?
Last, I do it fairly rarely because I don't drive much: I have yet to even approach 2,000 miles in almost a year. About once every two or three months now is it for me.
Wow ... let me know if and when you put your 2018 Leaf up for sale.

And again ... thx for your time and effort put into moderating and contributing your experience and expertise to this forum.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 7:04 am
I wasn't miffed, just using an economical posting method. It hurts a bit for me to type. I'd say that for typical drivers, balancing every two or three weeks is fine. If the car's range isn't taxed, or it isn't driven much, less often is probably fine as well. And yes, LeafSpy is how we know what the actual (if any LeafSpy reading can be called that, since it's just an interpretation of BMS messages) SOC figures are.

I'll almost certainly be turning in my leased 2018 SL, but if you want to pay the residual, fees etc, that (you buying it) can happen too.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 9:54 am
First rule of battery management; Make sure you have enough range to meet your needs.

Second Rule of Battery management; see Rule #1

If you are concerned about extra time at 100% charge...or 90% or whatever (its not an absolute. Its a sliding scale) and you have enough at 70% or whatever level to cover rule #1, then I suggest you don't balance at all.

Your cells balance all the time. The "only" advantage to top end balancing is getting a bit more range from a charge. Not charging to 100% is not going to result in a cumulative out of balance scenario.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 2:05 pm
The balance profile shown by LeafSpy does get more and more 'ragged' looking after a month, but the question remains of how much that really matters - except when maximum range is needed.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 2:11 pm
LeftieBiker wrote:The balance profile shown by LeafSpy does get more and more 'ragged' looking after a month, but the question remains of how much that really matters - except when maximum range is needed.
True that and what if any of that unbalance is permanent? Cause I doubt it is. So any level of unbalanced can be rectified by anywhere from several days to maybe as much as a few weeks of full charge cycles if planning a trip. In my experience, it usually only takes 3-4.

### Re: How often to "Cell Balance"? Weekly? Monthly? Depends?

Posted: Sun Feb 10, 2019 2:24 pm
My car goes back to perfect balance after one full charge - so far.